Bulletin Information

Bulletin Title: #91-C-51 - CAMPAIGN: SERVICE PART FUEL TANK SENDER RING WELDS - (Jun 1, 1995)
Bulletin Type: Campaign
Bulletin Category: Service Campaign
Applies To: Engine Controls / Rear Quarters

Applicable Vehicles

1991 Geo Tracker - 4WD
1991 Geo Tracker - 2WD
1991 Geo Storm
1991 Geo Sprint
1991 Geo Prizm
1991 Geo Metro
1991 Chevrolet V Truck - 4WD
1991 Chevrolet Suburban - 4WD
1991 Chevrolet Suburban - 2WD
1991 Chevrolet S10 Pickup - 4WD
1991 Chevrolet S10 Pickup - 2WD
1991 Chevrolet R Truck - 2WD
1991 Chevrolet P RV/Van/Commercial Chassis
1991 Chevrolet MD Steel Tilt 76.2"
1991 Chevrolet MD Steel Tilt 67.2"
1991 Chevrolet MD S Chassis
1991 Chevrolet MD P Bus Chassis
1991 Chevrolet MD Conventional (C Model)
1991 Chevrolet MD Bus Chassis (B Model)
1991 Chevrolet Lumina APV
1991 Chevrolet Lumina
1991 Chevrolet K Pickup - 4WD
1991 Chevrolet G Van
1991 Chevrolet Corvette
1991 Chevrolet Corsica
1991 Chevrolet Cavalier
1991 Chevrolet Caprice
1991 Chevrolet Camaro
1991 Chevrolet C Pickup - 2WD
1991 Chevrolet Blazer - 4WD
1991 Chevrolet Blazer - 2WD
1991 Chevrolet Beretta
1991 Chevrolet Astro - 4WD
1991 Chevrolet Astro - 2WD
1990 Geo Tracker - 4WD
1990 Geo Storm
1990 Geo Sprint
1990 Geo Prizm
1990 Geo Metro
1990 Chevrolet V Truck - 4WD
1990 Chevrolet Suburban - 4WD
1990 Chevrolet Suburban - 2WD
1990 Chevrolet S10 Pickup - 4WD
1990 Chevrolet S10 Pickup - 2WD
1990 Chevrolet R Truck - 2WD
1990 Chevrolet P RV/Van/Commercial Chassis
1990 Chevrolet MD Steel Tilt 76.2"
1990 Chevrolet MD Steel Tilt 67.2"
1990 Chevrolet MD P Bus Chassis
1990 Chevrolet MD FWD Control Chassis
1990 Chevrolet MD Conventional 97.5"
1990 Chevrolet MD Conventional (C Model)
1990 Chevrolet Lumina APV
1990 Chevrolet Lumina
1990 Chevrolet K Pickup - 4WD
1990 Chevrolet G Van
1990 Chevrolet Corvette
1990 Chevrolet Corsica
1990 Chevrolet Celebrity
1990 Chevrolet Cavalier
1990 Chevrolet Caprice
1990 Chevrolet Camaro
1990 Chevrolet C Pickup - 2WD
1990 Chevrolet Blazer - 4WD
1990 Chevrolet Blazer - 2WD
1990 Chevrolet Beretta
1990 Chevrolet Astro - 4WD
1990 Chevrolet Astro - 2WD
1989 Geo Tracker - 4WD
1989 Geo Sprint
1989 Geo Spectrum
1989 Geo Prizm
1989 Geo Metro
1989 Chevrolet V Truck - 4WD
1989 Chevrolet Suburban - 4WD
1989 Chevrolet Suburban - 2WD
1989 Chevrolet S10 Pickup - 4WD
1989 Chevrolet S10 Pickup - 2WD
1989 Chevrolet R Truck - 2WD
1989 Chevrolet P RV/Van/Commercial Chassis
1989 Chevrolet MD Steel Tilt 76.2"
1989 Chevrolet MD Steel Tilt 67.2"
1989 Chevrolet MD P Bus Chassis
1989 Chevrolet MD FWD Control Chassis
1989 Chevrolet MD Conventional 97.5"
1989 Chevrolet K Pickup - 4WD
1989 Chevrolet G Van
1989 Chevrolet Corvette
1989 Chevrolet Corsica
1989 Chevrolet Celebrity
1989 Chevrolet Cavalier
1989 Chevrolet Caprice
1989 Chevrolet Camaro
1989 Chevrolet C Pickup - 2WD
1989 Chevrolet Blazer - 4WD
1989 Chevrolet Blazer - 2WD
1989 Chevrolet Beretta
1989 Chevrolet Astro - 2WD
1988 Geo Sprint
1988 Geo Spectrum
1988 Chevrolet V Truck - 4WD
1988 Chevrolet Suburban - 4WD
1988 Chevrolet Suburban - 2WD
1988 Chevrolet S10 Pickup - 4WD
1988 Chevrolet S10 Pickup - 2WD
1988 Chevrolet R Truck - 2WD
1988 Chevrolet P RV/Van/Commercial Chassis
1988 Chevrolet Nova
1988 Chevrolet Monte Carlo
1988 Chevrolet MD Steel Tilt 76.2"
1988 Chevrolet MD Steel Tilt 67.2"
1988 Chevrolet MD P Bus Chassis
1988 Chevrolet MD FWD Control Chassis
1988 Chevrolet MD Conventional 97.5"
1988 Chevrolet K Pickup - 4WD
1988 Chevrolet G Van
1988 Chevrolet Corvette
1988 Chevrolet Corsica
1988 Chevrolet Celebrity
1988 Chevrolet Cavalier
1988 Chevrolet Caprice
1988 Chevrolet Camaro
1988 Chevrolet C Pickup - 2WD
1988 Chevrolet Blazer - 4WD
1988 Chevrolet Blazer - 2WD
1988 Chevrolet Beretta
1988 Chevrolet Astro - 2WD
1987 Geo Sprint
1987 Geo Spectrum
1987 Chevrolet V Truck - 4WD
1987 Chevrolet Suburban - 4WD
1987 Chevrolet Suburban - 2WD
1987 Chevrolet S10 Pickup - 4WD
1987 Chevrolet S10 Pickup - 2WD
1987 Chevrolet R Truck - 2WD
1987 Chevrolet P RV/Van/Commercial Chassis
1987 Chevrolet Nova
1987 Chevrolet Monte Carlo
1987 Chevrolet MD Steel Tilt 72.5"
1987 Chevrolet MD Steel Tilt 62.2"
1987 Chevrolet MD P Bus Chassis
1987 Chevrolet MD FWD Control Chassis
1987 Chevrolet MD Conventional 97.5"
1987 Chevrolet G Van
1987 Chevrolet El Camino
1987 Chevrolet Corvette
1987 Chevrolet Corsica
1987 Chevrolet Chevette
1987 Chevrolet Celebrity
1987 Chevrolet Cavalier
1987 Chevrolet Caprice
1987 Chevrolet Camaro
1987 Chevrolet Blazer - 4WD
1987 Chevrolet Blazer - 2WD
1987 Chevrolet Beretta
1987 Chevrolet Astro - 2WD
1986 Geo Sprint
1986 Geo Spectrum
1986 Chevrolet Suburban - 4WD
1986 Chevrolet Suburban - 2WD
1986 Chevrolet S10 Pickup - 4WD
1986 Chevrolet S10 Pickup - 2WD
1986 Chevrolet P RV/Van/Commercial Chassis
1986 Chevrolet Nova
1986 Chevrolet Monte Carlo
1986 Chevrolet MD Steel Tilt 72.5"
1986 Chevrolet MD Steel Tilt 62.2"
1986 Chevrolet MD P Bus Chassis
1986 Chevrolet MD FWD Control Chassis
1986 Chevrolet MD Conventional 97.5"
1986 Chevrolet K Pickup - 4WD
1986 Chevrolet G Van
1986 Chevrolet El Camino
1986 Chevrolet Corvette
1986 Chevrolet Chevette
1986 Chevrolet Celebrity
1986 Chevrolet Cavalier
1986 Chevrolet Caprice
1986 Chevrolet Camaro
1986 Chevrolet C Pickup - 2WD
1986 Chevrolet Blazer - 4WD
1986 Chevrolet Blazer - 2WD
1986 Chevrolet Astro - 2WD
1985 Geo Sprint
1985 Geo Spectrum
1985 Chevrolet Suburban - 4WD
1985 Chevrolet Suburban - 2WD
1985 Chevrolet S10 Pickup - 4WD
1985 Chevrolet S10 Pickup - 2WD
1985 Chevrolet P RV/Van/Commercial Chassis
1985 Chevrolet Nova
1985 Chevrolet Monte Carlo
1985 Chevrolet MD Steel Tilt 72.5"
1985 Chevrolet MD P Bus Chassis
1985 Chevrolet MD FWD Control Chassis
1985 Chevrolet MD Conventional 97.5"
1985 Chevrolet K Pickup - 4WD
1985 Chevrolet Impala
1985 Chevrolet G Van
1985 Chevrolet El Camino
1985 Chevrolet Corvette
1985 Chevrolet Citation
1985 Chevrolet Chevette
1985 Chevrolet Celebrity
1985 Chevrolet Cavalier
1985 Chevrolet Caprice
1985 Chevrolet Camaro
1985 Chevrolet C Pickup - 2WD
1985 Chevrolet Blazer - 4WD
1985 Chevrolet Blazer - 2WD
1985 Chevrolet Astro - 2WD
1984 Chevrolet Suburban - 4WD
1984 Chevrolet Suburban - 2WD
1984 Chevrolet S10 Pickup - 4WD
1984 Chevrolet S10 Pickup - 2WD
1984 Chevrolet P RV/Van/Commercial Chassis
1984 Chevrolet Monte Carlo
1984 Chevrolet MD Steel Tilt 72.5"
1984 Chevrolet MD Steel Tilt 71.75"
1984 Chevrolet MD P Bus Chassis
1984 Chevrolet MD FWD Control Chassis
1984 Chevrolet MD Conventional 97.5"
1984 Chevrolet K Pickup - 4WD
1984 Chevrolet Impala
1984 Chevrolet G Van
1984 Chevrolet El Camino
1984 Chevrolet Corvette
1984 Chevrolet Citation
1984 Chevrolet Chevette
1984 Chevrolet Celebrity
1984 Chevrolet Cavalier
1984 Chevrolet Caprice
1984 Chevrolet Camaro
1984 Chevrolet C Pickup - 2WD
1984 Chevrolet Blazer - 4WD
1984 Chevrolet Blazer - 2WD
1983 Chevrolet Suburban - 4WD
1983 Chevrolet Suburban - 2WD
1983 Chevrolet S10 Pickup - 4WD
1983 Chevrolet S10 Pickup - 2WD
1983 Chevrolet P RV/Van/Commercial Chassis
1983 Chevrolet Monte Carlo
1983 Chevrolet MD Steel Tilt 71.75"
1983 Chevrolet MD P Bus Chassis
1983 Chevrolet MD FWD Control Chassis
1983 Chevrolet MD Conventional 97.5"
1983 Chevrolet Malibu
1983 Chevrolet K Pickup - 4WD
1983 Chevrolet Impala
1983 Chevrolet G Van
1983 Chevrolet El Camino
1983 Chevrolet Corvette
1983 Chevrolet Citation
1983 Chevrolet Chevette
1983 Chevrolet Celebrity
1983 Chevrolet Cavalier
1983 Chevrolet Caprice
1983 Chevrolet Camaro
1983 Chevrolet C Pickup - 2WD
1983 Chevrolet Blazer - 4WD
1983 Chevrolet Blazer - 2WD
1982 Chevrolet Suburban - 4WD
1982 Chevrolet Suburban - 2WD
1982 Chevrolet S10 Pickup - 2WD
1982 Chevrolet P RV/Van/Commercial Chassis
1982 Chevrolet Monte Carlo
1982 Chevrolet MD Steel Tilt 71.75"
1982 Chevrolet MD P Bus Chassis
1982 Chevrolet MD FWD Control Chassis
1982 Chevrolet MD Conventional 97.5"
1982 Chevrolet Malibu
1982 Chevrolet Luv Truck - 4WD
1982 Chevrolet Luv Truck - 2WD
1982 Chevrolet K Pickup - 4WD
1982 Chevrolet Impala
1982 Chevrolet G Van
1982 Chevrolet El Camino
1982 Chevrolet Corvette
1982 Chevrolet Citation
1982 Chevrolet Chevette
1982 Chevrolet Celebrity
1982 Chevrolet Cavalier
1982 Chevrolet Caprice
1982 Chevrolet Camaro
1982 Chevrolet C Pickup - 2WD
1981 Chevrolet Suburban - 4WD
1981 Chevrolet Suburban - 2WD
1981 Chevrolet P RV/Van/Commercial Chassis
1981 Chevrolet Monte Carlo
1981 Chevrolet MD Steel Tilt 71.75"
1981 Chevrolet MD P Bus Chassis
1981 Chevrolet MD FWD Control Chassis
1981 Chevrolet MD Conventional 97.5"
1981 Chevrolet Malibu
1981 Chevrolet Luv Truck - 4WD
1981 Chevrolet Luv Truck - 2WD
1981 Chevrolet K Pickup - 4WD
1981 Chevrolet Impala
1981 Chevrolet G Van
1981 Chevrolet El Camino
1981 Chevrolet Corvette
1981 Chevrolet Citation
1981 Chevrolet Chevette
1981 Chevrolet Caprice
1981 Chevrolet Camaro
1981 Chevrolet C Pickup - 2WD
1981 Chevrolet Bel Air (Canada)
1980 Chevrolet Suburban - 4WD
1980 Chevrolet Suburban - 2WD
1980 Chevrolet P RV/Van/Commercial Chassis
1980 Chevrolet Monza
1980 Chevrolet Monte Carlo
1980 Chevrolet MD Steel Tilt 71.75"
1980 Chevrolet MD P Bus Chassis
1980 Chevrolet MD FWD Control Chassis
1980 Chevrolet MD Conventional 97.5"
1980 Chevrolet Malibu
1980 Chevrolet Luv Truck - 4WD
1980 Chevrolet Luv Truck - 2WD
1980 Chevrolet K Pickup - 4WD
1980 Chevrolet Impala
1980 Chevrolet G Van
1980 Chevrolet El Camino
1980 Chevrolet Corvette
1980 Chevrolet Citation
1980 Chevrolet Chevette
1980 Chevrolet Caprice
1980 Chevrolet Camaro
1980 Chevrolet C Pickup - 2WD
1980 Chevrolet Bel Air (Canada)

#91-C-51 - CAMPAIGN: SERVICE PART FUEL TANK SENDER RING WELDS - (Jun 1, 1995)

SUBJECT: SERVICE PART FUEL TANK SENDER RING WELDS

MODELS: 1975-86 GENERAL MOTORS CHEVROLET/GMC TRUCK C/K PICKUP AND CAB CHASSIS TRUCKS

1987-91 GENERAL MOTORS CHEVROLET/GMC TRUCK R/V PICKUP AND CAB CHASSIS TRUCKS

Dear General Motors Dealer:

This notice is sent to you in accordance w...

Attention!

To view the rest of this document requires a subscription. Subscriptions start at only $5.00. Click the button below to view the subscription options and to sign up.

Subscribe

Document Tags

Document Title: #91-C-51 - CAMPAIGN: SERVICE PART FUEL TANK SENDER RING WELDS - (Jun 1, 1995)

subject

service

part

fuel

tank

sender

ring

welds

models

general

chevrolet

truck

pickup

chassis

dealer

this

notice

accordance

national

traffic

motor

vehicle

safety

recall

defect

relates

exists

certain

recently

manufactured

replacement

gmspo

involved

gallon

pairs

projection

attach

unit

retaining

meet

specification

these

fracture

sending

installation

fractured

installer

could

spray

collision

leak

rolled

over

ignition

source

present

fire

occur

between

december

september

through

attached

letter

your

dealership

sales

inspection

determine

name

address

purchaser

owner

should

send

copy

requesting

their

campaign

bulletin

body

shop

independent

repair

contact

facility

obtain

copies

listed

number

code

mailed

appropriate

division

mail

product

dyke

judson

warren

pontiac

attentioncampaign

coordinator

attention

customer

notification

forward

addresses

involves

very

important

time

required

responsibly

identify

purchased

inventory

returned

credit

account

purchase

plus

allowance

handling

provide

form

customary

defective

return

described

policy

manual

type

reasonable

days

evidence

made

with

possible

assistance

center

remedy

condition

five

date

correct

inspect

corrosion

perform

pressure

test

suspect

system

expense

information

obtained

from

order

description

auxiliary

primary

that

submit

claim

searching

incurred

mailing

each

straps

excessive

existing

performing

have

replaced

advised

pass

removed

inspected

lifting

unevenness

surface

indication

further

verification

trying

feeler

gauge

charge

procedure

position

need

indicates

remove

indicated

section

disconnect

negative

battery

cable

electronic

radiator

pump

kent

moore

tool

equivalent

hose

fitting

applicable

vapor

line

canister

figure

dual

shield

below

reconnect

install

identification

label

using

replace

necessary

instructions

labor

record

search

includes

total

found

single

draining

removal

searched

hours

entered

administrative

operation

card

technicians

trucks general

motors dealer

safety exists

replacement fuel

fuel tanks

tanks general

motors service

service parts

tanks involved

gallon service

projection welds

welds attach

attach sender

sender unit

retaining ring

tank meet

sending unit

unit installation

service tanks

involved recall

gallon gallon

tanks service

purchasers replacement

tanks purchaser

owner vehicle

vehicle should

send owner

owner copy

copy attached

attached owner

owner letter

letter requesting

truck inspection

repair shop

repair facility

obtain owner

owner name

listed part

dealership name

dealer code

chevrolet motor

motor division

truck division

mail code

code product

attention campaign

campaign coordinator

vehicle owner

owner notification

recall involves

involves replacement

replacement parts

records customer

customer name

address very

important involved

involved dealer

dealer time

identify customers

customers purchased

purchased these

tanks inventory

returned gmspo

gmspo credit

provide replacement

part return

described parts

parts policy

policy procedures

reasonable time

customer assistance

tank determine

gallon tank

fuel systems

models required

primary gallon

required replaces

time searching

expense incurred

mailing owner

excessive corrosion

evidence lifting

tank surface

surface lifting

unevenness sender

ring indication

fractured welds

welds further

verification fractured

made trying

trying pass

pass feeler

gauge welds

tank fuel

remove fuel

service manual

radiator pressure

fuel vapor

line fuel

vapor canister

tank shield

tank system

tank replacement

campaign identification

inspect replace

existing fuel

claim information

information submit

information indicated

search owner

time allowance

allowance includes

name addresses

mailing chevrolet

truck copy

purchasers name

claim type

single tank

system inspect

includes draining

draining fuel

fuel required

tank includes

includes removal

removal tank

dual tank

inspect tanks

tanks includes

records searched

searched submit

total time

time total

time hours

hours times

number names

addresses found

found total

should entered

labor operation

operation time

time description

administrative time

required dual

chassis trucks general

trucks general motors

dear general motors

general motors dealer

requirements national traffic

reason recall general

recall general motors

general motors decided

motors decided defect

decided defect relates

vehicle safety exists

safety exists certain

replacement fuel tanks

fuel tanks general

tanks general motors

general motors service

motors service parts

operations gmspo tanks

gmspo tanks involved

tanks involved gallon

involved gallon service

part fuel tanks

fuel tanks used

projection welds attach

welds attach sender

attach sender unit

ring tank meet

tank meet specification

welds fracture sending

fracture sending unit

sending unit installation

unit installation welds

noticed installer tank

collision leak fuel

vehicle rolled over

service tanks involved

tanks involved recall

involved recall part

part tank size

tank size gallon

size gallon gallon

gallon gallon gallon

these tanks service

chassis trucks tanks

trucks tanks produced

address purchasers replacement

tanks purchaser owner

purchaser owner vehicle

owner vehicle should

send owner copy

owner copy attached

copy attached owner

attached owner letter

owner letter requesting

letter requesting their

independent repair shop

repair facility obtain

facility obtain owner

obtain owner name

owner name address

name address listed

address listed part

number dealership name

dealership name address

name address dealer

address dealer code

chevrolet motor division

truck division mail

division mail code

mail code product

code product campaigns

coordinator attention campaign

attention campaign coordinator

campaign coordinator subject

coordinator subject fuel

subject fuel tank

repair facility rather

than vehicle owner

vehicle owner contact

owner contact facility

facility obtain name

address vehicle owner

vehicle owner send

owner send customer

send customer copy

attached owner notification

owner notification letter

notification letter forward

letter forward names

addresses customers address

since recall involves

recall involves replacement

involves replacement parts

records customer name

customer name address

name address very

important involved dealer

involved dealer time

responsibly identify customers

identify customers purchased

customers purchased these

returned gmspo credit

gmspo credit account

handling provide replacement

part return described

return described parts

described parts policy

parts policy procedures

general motors corporation

customer assistance center

sender unit retaining

unit retaining ring

gallon tank replaces

diesel fuel systems

auxiliary primary gallon

models required replaces

fuel systems auxiliary

primary gallon tank

expense incurred mailing

incurred mailing owner

mailing owner letter

copies vehicle owner

vehicle owner name

name address each

listed part dealership

part dealership name

dealer code mailed

campaign coordinator recall

coordinator recall involves

fuel tank straps

tank straps evidence

straps evidence recent

excessive corrosion evidence

prior performing repair

been recently replaced

recently replaced evidence

replaced evidence excessive

evidence excessive corrosion

straps owner have

proof replacement fuel

replacement fuel tank

fuel tank purchased

tank purchased replaced

purchased replaced between

december september owner

advised vehicle involved

vehicle involved campaign

owner advised repairs

advised repairs made

repairs made fuel

tanks repairs correct

repairs correct fuel

correct fuel tanks

fuel tanks defective

retaining ring projection

ring projection welds

once inspection completed

inspection completed dealer

completed dealer should

then perform pressure

test suspect tank

suspect tank determine

their leaks tank

leaks tank pass

tank pass pressure

pass pressure test

fuel tank removed

tank removed sender

removed sender unit

inspected visually evidence

visually evidence lifting

evidence lifting unevenness

from tank surface

tank surface lifting

surface lifting unevenness

lifting unevenness sender

retaining ring indication

ring indication fractured

indication fractured welds

fractured welds further

verification fractured welds

fractured welds made

welds made trying

made trying pass

trying pass feeler

pass feeler gauge

feeler gauge welds

fractured sender unit

retaining ring welds

fuel tank transfer

remove fuel tank

service manual disconnect

radiator pressure test

pressurize fuel tank

threaded radiator pressure

radiator pressure tester

pressure tester hose

tester hose fitting

fuel vapor line

vapor line fuel

line fuel tank

fuel vapor canister

fuel tank vapor

tank vapor line

disconnect fuel tank

fuel tank replacement

tank replacement procedure

reconnect fuel vapor

reconnect negative battery

battery cable reset

cable reset electronic

install campaign identification

campaign identification label

appropriate service manual

filler neck hose

supporting fuel tank

fuel tank retaining

fuel tank sending

tank sending unit

wires hoses ground

using kent moore

install fuel tank

existing fuel tank

information submit claim

submit claim information

claim information indicated

record search owner

search owner name

time allowance includes

purchasers name addresses

single tank system

tank system inspect

includes draining fuel

draining fuel required

tank includes removal

includes removal tank

removal tank shield

dual tank system

system inspect tanks

draining fuel tanks

fuel tanks required

replace tanks includes

tanks includes removal

records searched submit

total time total

time total time

total time hours

time hours times

hours times total

number names addresses

names addresses found

addresses found total

found total time

should entered regular

entered regular labor

regular labor hours

labor operation time

operation time description

time description code

name address times

allowance includes time

includes time searching

truck copy purchasers

copy purchasers name

purchasers name address

dealer receive administrative

receive administrative time

administrative time allowance

associated campaign hour

campaign hour labor

hour labor operation

required dual tank